Unseen and often forgotten, fuel filters are a small but critical part of a vehicle’s fuel supply system.  It’s easy to forget about your car’s fuel filters, but you may regret it if you do. Here’s what you need to know to protect your fuel supply system and maintain a smooth ride.

Most vehicles have two fuel filters. There’s one in the fuel tank, often called a strainer (which costs $25 to $100) and one in the main fuel line (usually less than $20). The filter material is made from plastic or specially coated pleated paper. Fuel filters are designed to trap dirt, rust, scale and other impurities from entering the fuel pump, fuel injectors and engine, without effecting fuel pressure.

Gasoline fuel filters are rated in microns. Most modern vehicles with fuel-injection systems use filters rated between 10 and 30 microns. (A micron is .001mm. By comparison, a human hair is approximately 70 microns or .08mm.) This is critical because modern engines have extremely tight fuel system and engine component tolerances. Due to their abrasive nature, combined with the high fuel pressure of fuel-injected engines, any foreign particles that gets past a faulty or dirty fuel filter can cause blockages that interrupt the fuel supply and damage your engine.

Poor Engine Performance:  Under heavy loads, a clogged fuel filter may cause the engine to randomly hesitate, surge or sputter. This tends to be more prominent when accelerating, especially up a steep incline. Although there may be no symptoms under normal driving conditions, a clogged fuel filter will starve the engine of the extra fuel needed when quickly accelerating. Depending on the extent of the fuel restriction caused by a dirty filter, an engine may also shake or stutter at different speeds.

Hard Starting:  Unless totally blocked, rarely will a bad fuel filter keep your engine from starting. On a vehicle where a fuel filter has never been changed, the dirty filter can cause erratic fuel flow, resulting in longer than usual cranking before the engine starts. Check your owner’s manual on filter replacement intervals.

Stalling:  An engine that repeatedly stalls while driving could be warning you of a dirty fuel filter. Again, depending on the severity of the clog, your car may start right back up without any noticeable loss of power. As the clog worsens and fuel delivery becomes more sporadic, stalling becomes excessive or worsens on acceleration. It’s likely the filter is getting completely clogged and it’s time for a replacement.

Random Misfire or Rough Idle:  A clogged fuel filter causes low fuel pressure that results in a lean fuel condition and engine misfire. This can result in poor fuel mileage, rough idling and possibly cause the check engine light to come on. Once that light is on, it’s time for a trip to the repair shop.

Fuel System Part Failures:  A noisy, damaged or failed fuel pump can be the caused by a restricted fuel filter. A clogged fuel filter prevents the correct amount of fuel from reaching the engine. The fuel pump will try to compensate for a bad fuel filter, placing undue pressure on the fuel pump motor causing the pump to fail prematurely.  Contaminates that get past a dirty fuel filter can damage, clog or cause a fuel injector to leak, leading to all types of engine drivability problems. Unless totally failed, replacing a dirty fuel filter and servicing or flushing the injectors (done by the pros) should get you back on the road with minimal expense.

The main line fuel filter is replaceable. But before you go the DIY route, be sure the engine is cool, you have the proper tools, and you release fuel system pressure by pulling the fuel pump fuse (check the owner’s manual for its location) and running the engine until it shuts off. Releasing fuel pressure is critical because you do not want gas spraying all over the engine or ground. Be safe and have a fire extinguisher nearby anyway.  Or, if you are like me, make an appointment with your mechanic and let them check it.

Thanks to generous donations we were able to provide 19 families, representing 32 children, with car repairs in 2020.  Over $10 thousand dollars was spent directly on car repairs.  This represented 93% of all expenses. The remaining expenses went to postage and insurance.

In our 9 years of helping others, we have been able to provide services to 120 families.  We thank God for your generous donations that allow us serve Him in this critical need.

In addition to using the donation button on our website donate page, you can now help us with this importance service to our community in two new ways.

The first is through Arizona’s tax credit program. Restoration Rides Ministry is an approved qualified charitable organization. This means that you can now take advantage of the tax credit program offered by the State Of Arizona. As you consider year-end giving and your tax preparation for next year, you can make a donation of $800 for married tax taxpayers filing a joint return or $400 for single taxpayers. Our Qualifying Charitable Organization filing code is 22053. To qualify for the Arizona tax credit, our code number must be included when preparing your Arizona tax filing for 2020. Please consult your tax advisor for reporting requirements.

We are also happy to announce that Restoration Rides Ministry is now apart of the Amazon Smile program.  By logging on to smile.amazon.com when making your on-line purchases you can choose Restoration Rides Ministry as your non-profit of choice.  By searching and selecting Restoration Rides Ministry,  a percentage of your purchase price will go directly to our ministry at no cost to you. An easy, painless way to support us as we repair automobiles for those who can not afford repair expenses.

Will you please join us in this important out reach to needy families.  Since we have started, over 100 families have benefited from your generous donations.  Thank you.